DataSheet.es    


PDF FSBB20CH60L Data sheet ( Hoja de datos )

Número de pieza FSBB20CH60L
Descripción Smart Power Module
Fabricantes Fairchild Semiconductor 
Logotipo Fairchild Semiconductor Logotipo



Hay una vista previa y un enlace de descarga de FSBB20CH60L (archivo pdf) en la parte inferior de esta página.


Total 16 Páginas

No Preview Available ! FSBB20CH60L Hoja de datos, Descripción, Manual

FSBB20CH60L
Smart Power Module
December 2007
SPM TM
Features
• UL Certified No.E209204(SPM27-CB package)
• Very low thermal resistance due to using DBC
• 600V-20A 3-phase IGBT inverter bridge including control ICs
for gate driving and protection
• Divided negative dc-link terminals for inverter current sensing
applications
• Single-grounded power supply due to built-in HVIC
• Isolation rating of 2500Vrms/min.
Applications
• AC 100V ~ 253V three-phase inverter drive for small power
ac motor drives
• Home appliances applications like air conditioner and wash-
ing machine.
General Description
It is an advanced smart power module (SPMTM) that Fairchild
has newly developed and designed to provide very compact
and high performance ac motor drives mainly targeting low-
power inverter-driven application like air conditioner and wash-
ing machine. It combines optimized circuit protection and drive
matched to low-loss IGBTs. System reliability is further
enhanced by the integrated under-voltage lock-out and short-
circuit protection. The high speed built-in HVIC provides opto-
coupler-less single-supply IGBT gate driving capability that fur-
ther reduce the overall size of the inverter system design. Each
phase current of inverter can be monitored separately due to
the divided negative dc terminals.
Top View
44mm
www.DataSheet4U.com
26.8mm
Bottom View
Figure 1.
©2007 Fairchild Semiconductor Corporation
FSBB20CH60L Rev. C
1
www.fairchildsemi.com

1 page




FSBB20CH60L pdf
Absolute Maximum Ratings (TJ = 25°C, Unless Otherwise Specified)
Inverter Part
Symbol
Parameter
Conditions
Rating Units
VPN
VPN(Surge)
VCES
± IC
± ICP
PC
TJ
Supply Voltage
Supply Voltage (Surge)
Collector-emitter Voltage
Each IGBT Collector Current
Each IGBT Collector Current (Peak)
Collector Dissipation
Operating Junction Temperature
Applied between P- NU, NV, NW
Applied between P- NU, NV, NW
TC = 25°C
TC = 25°C, Under 1ms Pulse Width
TC = 25°C per One Chip
(Note 1)
450
500
600
20
40
61
-20 ~ 125
V
V
V
A
A
W
°C
Note:
1. The maximum junction temperature rating of the power chips integrated within the SPM is 150 °C(@TC 100°C). However, to insure safe operation of the SPM, the average
junction temperature should be limited to TJ(ave) 125°C (@TC 100°C)
Control Part
Symbol
Parameter
Conditions
Rating
VCC Control Supply Voltage
Applied between VCC(UH), VCC(VH), VCC(WH), VCC(L) -
COM
20
VBS High-side Control Bias
Voltage
Applied between VB(U) - VS(U), VB(V) - VS(V), VB(W) -
VS(W)
20
VIN Input Signal Voltage
Applied between IN(UH), IN(VH), IN(WH), IN(UL), IN(VL),
IN(WL) - COM
-0.3~17
VFO Fault Output Supply Voltage Applied between VFO - COM
-0.3~VCC+0.3
IFO Fault Output Current
Sink Current at VFO Pin
5
VSC Current Sensing Input Voltage Applied between CSC - COM
-0.3~VCC+0.3
Units
V
V
V
V
mA
V
Total System
Symbol
Parameter
VPN(PROT) Self Protection Supply Voltage Limit
(Short Circuit Protection Capability)
www.DataSheetT4CU.com Module Case Operation Temperature
TSTG
Storage Temperature
VISO
Isolation Voltage
Conditions
VCC = VBS = 13.5 ~ 16.5V
TJ = 125°C, Non-repetitive, less than 2μs
-20°CTJ 125°C, See Figure 2
60Hz, Sinusoidal, AC 1 minute, Connection
Pins to ceramic substrate
Rating
400
-20 ~ 100
-40 ~ 125
2500
Units
V
°C
°C
Vrms
Thermal Resistance
Symbol
Parameter
Condition
Rth(j-c)Q
Rth(j-c)F
Junction to Case Thermal Inverter IGBT part (per 1/6 module)
Resistance
Inverter FWD part (per 1/6 module)
Note:
2. For the measurement point of case temperature(TC), please refer to Figure 2.
Min.
-
-
Typ. Max. Units
- 1.63 °C/W
- 2.55 °C/W
FSBB20CH60L Rev. C
5
www.fairchildsemi.com

5 Page





FSBB20CH60L arduino
CPU
5V-Line
RPF=
4.7kΩ
100 Ω
1nF
CPF=
1nF
SPM
IN(UH) , IN (VH) , IN(W H)
IN (UL) , IN (VL) , IN(W L)
VF O
COM
Note:
1. RC coupling at each input (parts shown dotted) might change depending on the PWM control scheme used in the application and the wiring impedance of the application’s
printed circuit board. The SPM input signal section integrates 3.3kΩ(typ.) pull-down resistor. Therefore, when using an external filtering resistor, please pay attention to the sig-
nal voltage drop at input terminal.
2. The logic input is compatible with standard CMOS or LSTTL outputs.
Figure 9. Recommended CPU I/O Interface Circuit
These Values depend on PW M Control Algorithm
15V-Line
www.DataSheet4U.com
RBS
DBS
22uF
0.1uF
RE(H)
One-Leg Diagram of SPM
Vcc VB
IN HO
COM VS
P
1000uF
1uF
Vcc
IN OUT
COM VSL
Inverter
O utput
N
Note:
1. It would be recommended that the bootstrap diode, DBS, has soft and fast recovery characteristics.
2. The bootstrap resistor (RBS) should be 3 times greater than RE(H). The recommended value of RE(H) is 5.6Ω, but it can be increased up to 20Ω (maximum) for a slower dv/dt of
high-side.
3. The ceramic capacitor placed between VCC-COM should be over 1μF and mounted as close to the pins of the SPM as possible.
Figure 10. Recommended Bootstrap Operation Circuit and Parameters
FSBB20CH60L Rev. C
11
www.fairchildsemi.com

11 Page







PáginasTotal 16 Páginas
PDF Descargar[ Datasheet FSBB20CH60L.PDF ]




Hoja de datos destacado

Número de piezaDescripciónFabricantes
FSBB20CH60Smart Power ModuleFairchild Semiconductor
Fairchild Semiconductor
FSBB20CH60BTSmart Power ModuleFairchild Semiconductor
Fairchild Semiconductor
FSBB20CH60CSmart Power ModuleFairchild Semiconductor
Fairchild Semiconductor
FSBB20CH60CLSmart Power ModuleFairchild Semiconductor
Fairchild Semiconductor

Número de piezaDescripciónFabricantes
SLA6805M

High Voltage 3 phase Motor Driver IC.

Sanken
Sanken
SDC1742

12- and 14-Bit Hybrid Synchro / Resolver-to-Digital Converters.

Analog Devices
Analog Devices


DataSheet.es es una pagina web que funciona como un repositorio de manuales o hoja de datos de muchos de los productos más populares,
permitiéndote verlos en linea o descargarlos en PDF.


DataSheet.es    |   2020   |  Privacy Policy  |  Contacto  |  Buscar