|
|
PDF IRAMS06UP60B Data sheet ( Hoja de datos )
| Número de pieza | IRAMS06UP60B | |
| Descripción | Plug N Drive Integrated Power Module | |
| Fabricantes | International Rectifier | |
| Logotipo |  |
|
Hay una vista previa y un enlace de descarga de IRAMS06UP60B (archivo pdf) en la parte inferior de esta página. Total 18 Páginas | ||
|
No Preview Available !
www.DataSheet4U.com
PD-95832 RevC
IRAMS06UP60B
Series
Plug N DriveTM Integrated Power
Module for Appliance Motor Drive
Description
6A, 600V
with Internal Shunt Resistor
International Rectifier’s IRAMS06UP60B is an Integrated Power Module developed and optimized for
electronic motor control in appliance applications specifically for VF compressor drives for refrigerators and
freezer or in heating and ventilation as electronic fan controls. The IRAMS06UP60B offers an extremely
compact, high performance AC motor-driver in a single isolated package for a very simple design.
An internal shunt is included and offers easy current feedback and overcurrent monitor for precise control
and safe operation. A built-in temperature monitor and over-current protection, along with the short-circuit
rated IGBTs and integrated under-voltage lockout function, deliver high level of protection and fail-safe
operation. The integration of the bootstrap diodes for the high-side driver section, and the single polarity
power supply required to drive the internal circuitry, simplify the utilization of the module and deliver further
cost reduction advantages.
Features
• Internal Shunt Resistor
• Integrated Gate Drivers and Bootstrap Diodes
• Temperature Monitor
• Overcurrent shutdown
• Fully Isolated Package.
• Low VCE(on) Non Punch Through IGBT Technology
• Undervoltage lockout for all channels
• Matched propagation delay for all channels
• Schmitt-triggered input logic
• Cross-conduction prevention logic
• Lower di/dt gate driver for better noise
immunity
• Motor Power range 0.1~0.5kW / 85~253 Vac
• Isolation 2000VRMS /1min
Absolute Maximum Ratings
Parameter
Description
Max. Value
Units
VCES Maximum IGBT Blocking Voltage
V+ Positive Bus Input Voltage
600
V
450
Io @ TC=25°C
Io @ TC=100°C
Ipk
Fp
Pd
Viso
TJ (IGBT & Diodes)
TJ (Driver IC)
T
RMS Phase Current
RMS Phase Current
Max Peak Phase Current (tp<100ms) (see Note 1)
Maximum PWM Carrier Frequency
Maximum Power dissipation per Phase
Isolation Voltage (1min)
Operating Junction temperature Range
Operating Junction temperature Range
Mounting torque Range (M3 screw)
6
3
9
20
7.5
2000
-40 to +150
-40 to +150
0.8 to 1.0
A
kHz
W
VRMS
°C
Nm
Note 1: Limited by current protection, see table "Inverter Section Electrical Characteristics" on page 3
www.irf.com
1
1 page  
IRAMS06UP60B
Dynamic Electrical Characteristics
VDD=VBS=VBIAS=15V, PWMIN=2kHz, VIN_ON=VIN_th+, VIN_OFF=VIN_th-
TA=25°C, unless otherwise specified
Symbol
TON
TOFF
DT
I/TTrip
TFCLTRL
Definition
Input to output propagation turn-on delay time (see fig.11)
Input to output propagation turn-off delay time (see fig. 11)
Dead Time
T/ITrip to six switch to turn-off propagation delay (see fig. 2)
Post ITrip to six switch to turn-off clear time (see fig. 2)
Min Typ Max Units
- 470 -
ns
- 615 -
ns
- 290 -
ns
- 750 -
ns
- 9 - ms
Internal NTC - Thermistor Characteristics
Parameter
R25 Resistance
R125 Resistance
B B-constant (25-50°C)
Temperature Range
Typ. Dissipation constant
Typ
100 +/- 3%
2.522 ±10.9%
4250 +/- 2%
-40 / 125
1
Units
kΩ
kΩ
k
°C
mW/°C
Internal Current Sensing Resistor - Shunt Characteristics
Conditions
TC = 25°C
TC = 125°C
R2 = R1e [B(1/T2 - 1/T1)]
TC = 25°C
Parameter
Resistance
Tollerance
Max Power Dissipation
Temperature Range
50 ±1%
±1%
1.5
-40 / 125
Units
mΩ
W
°C
Note 2: For more details, see IR21363 data sheet
Note 3: Logic operational for Vs from V- -5V to V- +600V. Logic state held for Vs from V- -5V to V- -VBS. (please refer to
DT97-3 for more details)
Thermistor Built-in IRAMS06UP60B
ITRIP (22)
FLT (21)
Thermistor (13)
VSS (23)
NTC
Driver IC
Note 4: The Maximum recommended sense voltage at the ITRIP terminal under normal operating conditions is 3.3V.
www.irf.com
5
5 Page 
IRAMS06UP60B
9
8
7
6
5
4
3
2
1
0
-1
0.000
0.100
0.200
0.300
0.400 0.500 0.600
Time (µs)
0.700
Current
Voltage
0.800 0.900
450
400
350
300
250
200
150
100
50
0
-50
1.000
Figure 5. IGBT Turn-on. Typical turn-on waveform @Tj=125°C, V+=400V
4.5
4
3.5
3
2.5
2
1.5
1
0.5
0
-0.5
0.000
0.100
0.200
0.300
0.400 0.500 0.600
Time (µs)
Current
Voltage
0.700 0.800
0.900
450
400
350
300
250
200
150
100
50
0
-50
1.000
Figure 6. IGBT Turn-off. Typical turn-off waveform @Tj=125°C, V+=400V
www.irf.com
11
11 Page | ||
| Páginas | Total 18 Páginas | |
| PDF Descargar | [ Datasheet IRAMS06UP60B.PDF ] | |
Hoja de datos destacado
| Número de pieza | Descripción | Fabricantes |
| IRAMS06UP60A | Plug N DriveTM Integrated Power Module | International Rectifier |
| IRAMS06UP60B | Plug N Drive Integrated Power Module | International Rectifier |
| Número de pieza | Descripción | Fabricantes |
| SLA6805M | High Voltage 3 phase Motor Driver IC. |
 Sanken |
| SDC1742 | 12- and 14-Bit Hybrid Synchro / Resolver-to-Digital Converters. |
 Analog Devices |
|
DataSheet.es es una pagina web que funciona como un repositorio de manuales o hoja de datos de muchos de los productos más populares, |
| DataSheet.es | 2020 | Privacy Policy | Contacto | Buscar |