|
|
Número de pieza | IRAMS10UP60B | |
Descripción | Plug N DriveTM Integrated Power Module for Appliance Motor Drive | |
Fabricantes | International Rectifier | |
Logotipo | ||
Hay una vista previa y un enlace de descarga de IRAMS10UP60B (archivo pdf) en la parte inferior de esta página. Total 18 Páginas | ||
No Preview Available ! PD-95830 RevB
IRAMS10UP60B
Series
Plug N DriveTM Integrated Power
Module for Appliance Motor Drive
Description
10A, 600V
with Internal Shunt Resistor
International Rectifier's IRAMS10UP60B is an Integrated Power Module developed and optimized for electronic
motor control in appliance applications such as washing machines and refrigerators. Plug N Drive technology
offers an extremely compact, high performance AC motor-driver in a single isolated package for a very
simple design. An internal shunt is also included and offers easy current feedback and overcurrent monitor
for precise and safe operation. A built-in temperature monitor and over-current protection, along with the
short-circuit rated IGBTs and integrated under-voltage lockout function, deliver high level of protection and
fail-safe operation. The integration of the bootstrap diodes for the high-side driver section, and the single
polarity power supply required to drive the internal circuitry, simplify the utilization of the module and deliver
further cost reduction advantages.
Features
• Internal Shunt Resistor
• Integrated Gate Drivers and Bootstrap Diodes
• Temperature Monitor
• Fully Isolated Package
• Low VCE(on) Non Punch Through IGBT
Technology
• Undervoltage lockout for all channels
• Matched propagation delay for all channels
• Schmitt-triggered input logic
• Cross-conduction prevention logic
• Lower di/dt gate driver for better noise
immunity
• Motor Power range 0.4~0.75kW / 85~253 Vac
• Isolation 2000VRMS /1min
Absolute Maximum Ratings
Parameter
Description
Max. Value
VCES
V+
Io @ TC=25°C
Io @ TC=100°C
Ipk
Fp
Pd
Viso
TJ (IGBT & Diodes)
TJ (Driver IC)
T
Maximum IGBT Blocking Voltage
Positive Bus Input Voltage
RMS Phase Current (see Note 1)
RMS Phase Current (see Note 1)
Maximum Peak Phase Current (tp<100ms)
Maximum PWM Carrier Frequency
Maximum Power dissipation per Phase
Isolation Voltage (1min)
Operating Junction temperature Range
Operating Junction temperature Range
Mounting torque Range (M3 screw)
600
450
10
5
15
20
20
2000
-40 to +150
-40 to +150
0.8 to 1.0
Note 1: Limited by current protection, see table "Inverter Section Electrical Characteristics" on page 3
www.irf.com
Units
V
A
kHz
W
VRMS
°C
Nm
1
1 page IRAMS10UP60B
Dynamic Electrical Characteristics
VDD=VBS=VBIAS=15V, PWMIN=2kHz, VIN_ON=VIN_th+, VIN_OFF=VIN_th-
TA=25°C, unless otherwise specified
Symbol
TON
TOFF
DT
I/TTrip
TFCLTRL
Definition
Input to output propagation turn-on delay time (see fig.11)
Input to output propagation turn-off delay time (see fig. 11)
Dead Time
T/ITrip to six switch to turn-off propagation delay (see fig. 2)
Post ITrip to six switch to turn-off clear time (see fig. 2)
Min Typ Max Units
- 470 -
ns
- 615 -
ns
- 290 -
ns
- 750 -
ns
- 9 - ms
Internal NTC - Thermistor Characteristics
Parameter
R25 Resistance
R125 Resistance
B B-constant (25-50°C)
Temperature Range
Typ. Dissipation constant
Typ
100 +/- 3%
2.522 ± 10.9%
4250 +/- 2%
-40 / 125
1
Units
kΩ
kΩ
k
°C
mW/°C
Internal Current Sensing Resistor - Shunt Characteristics
Conditions
TC = 25°C
TC = 125°C
R2 = R1e [B(1/T2 - 1/T1)]
TC = 25°C
Parameter
Resistance
Tollerance
Max Power Dissipation
Temperature Range
33.3 ±1%
±1%
2.2
-40 / 125
Units
mΩ
W
°C
Note 2: For more details, see IR21363 data sheet
Note 3: Logic operational for Vs from V- -5V to V- +600V. Logic state held for Vs from V- -5V to V- -VBS. (please refer to
DT97-3 for more details)
Thermistor Built-in IRAMS10UP60B
ITRIP (22)
FLT (21)
VTH (13)
VSS (23)
NTC
Driver IC
www.irf.com
5
5 Page IRAMS10UP60B
9
8 Current
7 Voltage
6
5
4
3
2
1
0
-1
0.0 0.1 0.2 0.3 0.4 0.5 0.6 0.7 0.8 0.9
Time (µs)
Figure 5. IGBT Turn-on. Typical turn-on waveform @TJ=150°C, V+=400V
450
400
350
300
250
200
150
100
50
0
-50
1.0
9
8
7
6 Current
5 Voltage
4
3
2
1
0
-1
0.0 0.1 0.2 0.3 0.4 0.5 0.6 0.7 0.8 0.9
Time (µs)
Figure 6. IGBT Turn-off. Typical turn-off waveform @TJ=150°C, V+=400V
450
400
350
300
250
200
150
100
50
0
-50
1.0
www.irf.com
11
11 Page |
Páginas | Total 18 Páginas | |
PDF Descargar | [ Datasheet IRAMS10UP60B.PDF ] |
Número de pieza | Descripción | Fabricantes |
IRAMS10UP60A | Plug N Drive Integrated Power Module for Appliance Motor Drive | International Rectifier |
IRAMS10UP60B | Plug N DriveTM Integrated Power Module for Appliance Motor Drive | International Rectifier |
Número de pieza | Descripción | Fabricantes |
SLA6805M | High Voltage 3 phase Motor Driver IC. |
Sanken |
SDC1742 | 12- and 14-Bit Hybrid Synchro / Resolver-to-Digital Converters. |
Analog Devices |
DataSheet.es es una pagina web que funciona como un repositorio de manuales o hoja de datos de muchos de los productos más populares, |
DataSheet.es | 2020 | Privacy Policy | Contacto | Buscar |